Language selection

Air transportation safety recommendation A06-10

Reassessment of responses to Aviation Safety Recommendation A06-10

Existing production aircraft

 Recommendation 06-10 in PDF [168 KB]

Background

On 30 May 2000, the pilot of a Cessna 177B Cardinal was attempting to take off from a grass airstrip at Calling Lake, Alberta. The aircraft struck trees during the initial climb, struck the ground, and burst into flame. The two occupants were exposed to smoke and flame for some time. One occupant was fatally injured due to the effects of fire, and one sustained serious burns.

The accident investigation identified fuel system crashworthiness as a small-aircraft safety deficiency. In light of that finding, the Transportation Safety Board of Canada (TSB) identified a need to examine the extent to which fuel system crashworthiness and other safety deficiencies contribute to the risks associated with post-impact fire (PIF) in otherwise survivable accidents, and to consider the risk control options available to mitigate those risks.

According to TSB data from 1976 to 2002, PIF occurs in approximately 4 per cent of accidents involving small aircraft; however, these accidents account for approximately 22 per cent of the fatalities and 11 per cent of the serious injuries caused by all accidents. Overall, 6.2 per cent of fatal injuries and 3.8 per cent of serious injuries that resulted from small-aircraft PIF accidents were related to fire. Because small aircraft have a higher accident rate with a correspondingly greater number of PIF accidents, more defences are required to mitigate the risk of PIF. Considering these factors, the Board identified the need to conduct a Safety Issues Investigation.

The Board concluded its investigation and released report SII A05-01 on 29 August 2006.

Board Recommendation A06-10 (29 August 2006)

There are a large number of small aircraft already in service and the defences against PIF in impact-survivable accidents involving these aircraft are and will remain inadequate unless countermeasures are introduced to reduce the risk. The most effective ways to prevent PIF in accidents involving existing small aircraft are to eliminate potential ignition sources, such as hot items, high-temperature electrical arcing and friction sparking, and prevent fuel spillage by preserving fuel system integrity in survivable crash conditions. Technology that is known to reduce the incidence of PIF by preventing ignition and containing fuel in crash conditions may be selectively retrofitted to existing small aircraft, including helicopters certified before 1994. Therefore, the Board recommended that:

To reduce the number of post-impact fires in impact-survivable accidents involving existing production aircraft weighing less than 5700 kg, Transport Canada, the Federal Aviation Administration, and other foreign regulators conduct risk assessments to determine the feasibility of retrofitting aircraft with the following:

  • selected technology to eliminate hot items as a potential ignition source;
  • technology designed to inert the battery and electrical systems at impact to eliminate high-temperature electrical arcing as a potential ignition source;
  • protective or sacrificial insulating materials in locations that are vulnerable to friction heating and sparking during accidents to eliminate friction sparking as a potential ignition source; and
  • selected fuel system crashworthiness components that retain fuel.

Transportation Safety Recommendation A06-10

Transport Canada's responses to A06-10 (20 November 2006 and 29 January 2007)

Transport Canada's (TC) response dated 20 November 2006 states that it is not aware of any aviation industry initiatives to retrofit production aircraft in the manner suggested in Recommendation A06-10. Furthermore, it states that, until such technology is available, viable and required, it cannot conduct a risk assessment or mandate a retrofit to production aircraft. It concludes by stating that a study would be required to clearly identify the benefit of such an undertaking. The final paragraph of the response states that the Department is not in a position to commit the necessary resources at this time.

In its second response dated 29 January 2007, TC states that it would be inappropriate for TC to mandate changes to current production aircraft as suggested in Recommendation A06-10. TC indicates that it will review design proposals from industry in light of TSB's recommendations to assure that such modifications meet the highest standards possible.

Board Assessment of the Responses to A06-10 (12 September 2007)

TC's initial response dated 20 November 2006 states that it cannot conduct a risk assessment to determine the feasibility of retrofitting aircraft, as suggested in Recommendation A06-10, because a study must first be undertaken to establish that pertinent technologies are available, viable and required. No action plan to conduct such a study is provided in TC's response.

TC's follow-up response dated 29 January 2007 states that mandating changes to current production aircraft as suggested in Recommendation A06-10 would be inappropriate. This statement is incongruous as Recommendation A06-10 makes no mention of mandating changes but rather suggests that risk assessments be conducted. In lieu of any TC initiative to conduct risk assessments, TC would react to technology proposals from industry to ensure that such modifications meet the highest standards.

Because TC's responses contain no action or proposed action that will reduce or eliminate the risks associated with this deficiency, TC's overall response to Recommendation A06-10 is assessed as Unsatisfactory.

Transport Canada Response to A06-10 (15 February 2010)

TC's response indicates that it supports the TSB objective of reducing fatalities and serious injuries due to post-impact fires in general aviation aircraft however; implementation of these recommendations would require an immense resource effort. The response further states that other safety initiatives have a higher priority.

Board Assessment of the Response to A06-10 (28 July 2010)

TC's latest response makes no effort to explain its conclusions that an immense resource effort would be required to execute the objectives of Recommendation A06-10 and that such resources would detract from other safety initiatives.

Meanwhile the post-impact fire experience remains high. Preliminary research reveals that since 01 January 2005 the Board has recorded 99 occurrences that involve a post-impact fire phase/event combination. The majority of these occurrences involved aircraft weighing less than 5700 kg. A word string search of the NTSB database for the same timeframe turned up records of over 300 general aviation accidents where post-impact fire is referenced.

Again TC has failed to address the risks associated with the deficiency identified in Recommendation A06-10 it would appear that TC has in fact declared that it plans no further action.

Because TC's responses contain no action or proposed action that will reduce or eliminate the risks associated with this deficiency, the overall response to Recommendation A06-10 is assessed as Unsatisfactory.

Board Review of A06-10 Deficiency File Status (11 October 2012 as amended on 03 April 2013)

The Board notes that a review of the TSB's Aviation Safety Information System reveals that the PIF experience continues. From 01 January 2005 to 09 October 2012, the TSB recorded 93 occurrences of aircraft weighing less than 5700 kg that included a PIF phase/event combination.

The Board believes that the risks identified in Recommendation A06-10 have not abated and remain substantial. The Board therefore determined that these risks deserve a renewed effort by TSB to improve its data gathering of PIF-related events, and that TC should take appropriate safety actions to mitigate the risks associated with Recommendation A06-10 in order to reduce injuries and death associated with PIF.

Response of the Federal Aviation Administration to Recommendation A06-10 (November 2012)

TSB Safety recommendations A06-09 and A06-10 were responded to by the FAA on December 21, 2007. [This response was again faxed to Mr. Joliceour(sic) on November 12, 2012.] As you will note from our response, we believe that many of the TSBC's concerns were already addressed through various amendments to our part 23 regulations. Additionally, some of the TSBC concerns would require additional rulemaking, which the FAA could not justify from service history. Therefore, TSB recommendations A06-09 and A06-10 were classified as “Closed,” with no further FAA activity planned.

Transport Canada's response to Recommendation A06-10 (December 2012)

TCCA is aware of the Federal Aviation Administration (FAA)'s work in the 1980s leading to the notice of proposed rule-making (NPRM) 85-7A, titled 14 CFR Part 23 Airworthiness Standards: Crash-Resistant Fuel Systems, issued on 28 February 1990. The NPRM was subsequently withdrawn on 28 February 1999. The NPRM 85-7A withdrawal notice stated that the FAA had completed a revised economic evaluation of the safety recommendations as a result of the comments received and concluded that the costs of the proposed changes were not justified by the potential benefits, in addition to identifying some technical questions that remained unanswered.

As the TSB has asserted, some estimates of VSL have increased in the intervening years. However, TCCA would observe that the costs of aircraft modification have also increased in this period, by a factor that may have outpaced the VSL. Therefore, it may be unlikely that a revised economic analysis would yield a different outcome at this time. Consequently, TCCA would be unable to satisfy CDSR criteria in putting forward new rulemaking on this subject. However, work in other areas of GA safety is progressing that is likely to have a more holistically positive effect.

It has been noted that, despite all the advancements in design standards since the 1960s, the FAA observes that only 7% of the general aviation fleet has a modern set of applicable standards in its basis of certification. As many as 93% of general aviation airplanes in operation today have a basis of certification dating back to Civil Air Regulation (CAR) 3, designed in the 1950s through 1970s. The main barrier to the introduction of newer airplanes to the GA market is cost. Substantial fleet renewal with newer model airplanes, meeting the latest design standards, is necessary to obtain significant improvement in GA safety.

A holistic approach to renewing the GA sector, and its safety, is presently underway with the FAA's Part 23 ARC. An international group of aviation authorities and industry are currently redesigning the requirements for “Part 23” airplanes in an attempt to accomplish two goals: improve safety by a factor of two, and reduce costs to certify by half. The reduction of costs is necessary to enable the GA fleet renewal that would be necessary to obtain a fleet-wide safety improvement; the safety of the existing legacy and aging fleet of GA airplanes cannot be expected to improve with time.

In particular, the hope for the reorganization of Part 23 would be to facilitate the introduction of lifesaving technologies in GA airplanes in an attempt to reduce fatal accidents by half (i.e. loss of control (stall/spin close to ground), controlled flight into terrain, and engine mismanagement, collectively contributing to 50% of all GA accidents). A secondary objective is to reduce type certification (and production certification) costs by half.

FAA, TCCA, EASA, ANAC-Brazil and other aviation authorities are focussing on this vision for general aviation for the next 25 years, a vision that offers an economically viable means to have an overall improvement in GA safety.

Board reassessment of Transport Canada's response to Recommendation A06-10 (March 2013)

This Transport Canada response does not specifically reference Recommendation A06-10.

The response references FAA Part 23 ANC and it is known that the FAA convened a 55 member FAA Part 23 Aviation Rulemaking Committee (ARC) in August 2011 to look at simplifying the Part 23 regulations. The goal is to improve small aircraft safety by a factor of two and to reduce certification costs by half. There is strong international involvement, including Transport Canada and EASA. The TSB recognizes it may be easier to mandate the necessary post-impact fire countermeasures into Federal Aviation Regulations (FAR) 23 in the future, if the FAR 23 regulations are simplified and certification costs are reduced as a result of Part 23 ARC work.

Since the last Transport Canada response to A06-10 was received on 15 February 2010, it appears Transport Canada has taken no action to conduct a risk assessment to determine the feasibility of retrofitting small aircraft with selected technology to reduce the risk and impact of post-impact fires; as well it appears no further Transport Canada activity specific to A06-10 is planned.

Board reassessment of the Federal Aviation Administration's response to Recommendation A06-10 (March 2013)

Note that the FAA responded jointly to A06-09 and A06-10 in one paragraph.

The TSB disagrees with the FAA view that many of the TSB's concerns have already been addressed through various amendments of the FAA Part 23 regulations. All of the rulemakings referred to in the original response predate the publication of the TSB post-impact fire report by several years, and the majority of the references appear to exist primarily to reduce the risk of in-flight fires. As well, there are currently no specific requirements for retrofitting of small aircraft to reduce the incidence and impact of post-impact fires.

The TSB disagrees with the FAA view that additional rulemaking pertaining to post-impact fire countermeasures cannot be justified based on service history. The TSB notes that the primary service history aviation database is the service difficulty reporting (SDR) database. As the service difficulty database is not an accident database it is an unsuitable source of data for post-impact fire analysis, and therefore an unsuitable database to use as a basis to reject additional rulemaking. More appropriate databases for post-crash fire analysis are the NTSB database and the TSB database, both of which continues to record significant numbers of small aircraft post-impact fire accidents each year.

While the FAA is unwilling to act on Recommendation A06-10 at present, it is known that the FAA convened a 55 member FAA Part 23 Aviation Rulemaking Committee (ARC) in August 2011 to look at simplifying the Part 23 regulations. The goal is to improve small aircraft safety by a factor of two and to reduce certification costs by half. There is strong international involvement, including Transport Canada and EASA. The TSB recognizes it may be easier to mandate selected post-impact fire countermeasures into existing production aircraft in the future, if the FAR 23 regulations are simplified and certification costs are reduced as a result of Part 23 ARC work.

Since 2008, the FAA has taken no action to conduct a risk assessment to determine the feasibility of retrofitting small aircraft with selected technology to reduce the risk and impact of post-impact fires; as well no further FAA activity is planned.

Board reassessment of the responses from Transport Canada and the Federal Aviation Administration to Recommendation A06-10 (March 2013)

The Board believes that the risks identified in Recommendation A06-10 have not abated and remain significant. The Board therefore determined that these risks deserve a renewed effort by TSB to improve its data gathering of PIF-related events. In addition, the Board believes that Transport Canada and the FAA should consider appropriate safety actions, including conducting risk assessments to determine the feasibility of retrofitting existing production aircraft to mitigate the risks associated with Recommendation A06-10, in order to reduce injuries and death associated with post-impact fire. While the primary focus of FAR 23 ARC, as described by Transport Canada, appears to be the introduction of life saving technologies to prevent accidents, the TSB considers the Part 23 ARC deliberations an opportune time for regulators and industry to consider the feasibility of retrofitting existing production aircraft in order to reduce the risk and impact of post-impact fire when accidents occur.

To date, no action has been taken or proposed that will reduce or eliminate the deficiency.

Therefore, the responses in aggregate are assessed as Unsatisfactory.

Transport Canada's response to Recommendation A06-10 (November 2013)

TC's response dated 26 November 2013 stated that it had provided a detailed response in December 2012 with respect to the department's approach and work in this. Transport Canada will continue to monitor these issues in the context of working with the FAA and other regulatory authorities.

Response of the Federal Aviation Administration to Recommendation A06-10 (November 2013)

The FAA's response dated 14 November 2013 restated its response from December 2007 and again on November 2012. In these responses the FAA indicated that many of the TSB's concerns were already addressed through various amendments to part 23 of the FARs and that any additional rulemaking could not be justified after reviewing the aircraft service history. These recommendations (A06-09 and A06-10) were classified closed and no future activity is planned.

Board reassessment of the responses to Recommendation A06-10 (April 2014)

On 05 June 2013, a report from the 14 CFR Part 23 Reorganization Aviation Rulemaking Committee (ARC) to the FAA was issued containing recommendations for increasing the safety of small general aviation airplanes certificated to 14 CFR part 23. The report contained no specific language to retrofitting existing aircraft with technology noted in Recommendation A06-10, but did state that implementation of the ARC's recommendations would result in:

…safer new airplanes and improvements in the safety of existing fleet through the ability to more easily and rapidly incorporate new technology that can reduce pilot workload provide better situation awareness and afford other safety enhancements. It also has the potential for a significant reduction of certification costs through reduced need for Special Conditions, Equivalent Level of Safety findings or other activities.

Although encouraged by the FAA's efforts to amend the certification process, the Board believes that the risks identified in Recommendation A06-10 have not abated and remain significant.

To date, no direct action has been taken or proposed that will reduce or eliminate the deficiency.

Therefore, the overall response to Recommendation A06-10 is assessed as Unsatisfactory.

Response of the Federal Aviation Administration to Recommendation A06-10 (November 2014)

Thank you for providing us with the Transport Safety Board of Canada's Annual Reassessment of Active Aviation Recommendations for year 2014/2015. Your recommendations in question; A11-02, A11-01, A06-10 and A06-09, have been addressed in last year's FAA response to your annual reassessment and were considered closed, with no further action planned by the FAA.

Transport Canada's response to Recommendation A06-10 (January 2015)

Note that Transport Canada responded jointly to A06-09 and A06-10 with the following.

Transport Canada does not agree with the recommendation, and over the past few years has provided a detailed response with respect to the department's approach and work in this area.

As opposed to dealing with post impact fires as a separate issue, as stated in Transport Canada's December 2012 update, a holistic approach to renewing the GA sector, and its safety, is presently underway with the FAA's Part 23 ARC. An international group of aviation authorities and industry are currently redesigning the requirements for “Part 23” airplanes in an attempt to accomplish two goals: improve safety by a factor of two, and reduce costs to certify by half. The reduction of costs is necessary to enable the GA fleet renewal that would be necessary to obtain a fleet-wide safety improvement; the safety of the existing legacy and aging fleet of GA airplanes cannot be expected to improve with time.

Transport Canada will continue to monitor post-impact fire events as part of our ongoing work. Transport Canada considers this recommendation closed.

Board reassessment of the responses to Recommendation A06-10 (March 2015)

The Board believes that Transport Canada should consider appropriate safety actions, including conducting risk assessments to determine the feasibility of retrofitting existing production aircraft to mitigate the risks associated with Recommendation A06-10, in order to reduce injuries and death associated with post-impact fire.

The Board notes that a review of the TSB's Aviation Safety Information System reveals that the PIF experience continues. From 09 October 2012 to 15 January 2015, the TSB recorded 6Footnote 1 survivable accidents in aircraft weighing less than 5700 kg where there was a post impact fire. Fire was responsible for 4 fatalities, 8 serious injuries and 1 minor injury in these accidents.

The Board believes that TC should take appropriate safety actions to mitigate the risks associated with Recommendation A06-10 in order to reduce injuries and death associated with PIF.

To date, no direct action has been taken or proposed that will reduce or eliminate the deficiency.

Therefore, the overall response to Recommendation A06-10 is assessed as Unsatisfactory.

Transport Canada's response to Recommendation A06-10 (November 2015)

Note that Transport Canada responded jointly to A06-09 and A06-10 with the following:

As per the 2014 update, Transport Canada does not agree with the recommendation, and over the past few years has provided a detailed response with respect to the department's approach and work in this area.

2014 update:

As opposed to dealing with post impact fires as a separate issue, as stated in Transport Canada's December 2012 update, a holistic approach to renewing the GA sector, and its safety, is presently underway with the FAA's Part 23 ARC. An international group of aviation authorities and industry are currently redesigning the requirements for “Part 23” airplanes in an attempt to accomplish two goals: improve safety by a factor of two, and reduce costs to certify by half. The reduction of costs is necessary to enable the GA fleet renewal that would be necessary to obtain a fleet-wide safety improvement; the safety of the existing legacy and aging fleet of GA airplanes cannot be expected to improve with time. Transport Canada will continue to monitor post-impact fire events as part of our ongoing work.

Board reassessment of the response to Recommendation A06-10 (March 2016)

There has been no new response from the Federal Aviation Administration (FAA) as of 14 December 2015. The last response from the FAA, in November 2014, indicated that they considered the recommendation closed and proposed no further action beyond amending the certification process for Federal Aviation Regulations (FAR) 23 aircraft.

The Board believes that the risks identified in Recommendation A06-10 have not abated and remain significant. To date, no direct action has been taken or proposed that will reduce or eliminate the deficiency. Therefore, the overall response to Recommendation A06-10 is assessed as Unsatisfactory.

Transport Canada's response to Recommendation A06-10 (January 2017)

TC does not agree with the recommendation, and has provided a detailed response with respect to the Department's approach and work in this area.

TC has no further activities planned on this recommendation, but will continue to monitor the effect of new design standards on the rate of PIFs in new construction.

TSB reassessment of Transport Canada's response to Recommendation A06-10 (March 2017)

TC's response indicates that it does not agree with the recommendation and has no further planned activities to address the risks identified in Recommendation A06-10.

The FAA has not provided any new response to Recommendation A06-10 since November 2014. The last response from the FAA indicated that it considers the recommendation closed and proposes no further action beyond amending the certification process for FAR 23 aircraft.

The FAA released the amended certification process for FAR 23 aircraft in December 2016. The amendments addressed the hazards of in-flight fires but did not address crashworthiness and the prevention of PIF in either electrical or fuel systems.

The Board believes that the risks identified in Recommendation A06-10 have not decreased and remain significant. Since January 2015, there have been 4 survivable aircraft accidentsFootnote 2 in Canada that resulted in PIF, in which occupants suffered injuries ranging from minor to fatal (2 minor injuries, 2 serious injuries and 2 fatalities). There has been no direct action taken or proposed by either TC or the FAA that will reduce or eliminate the deficiency identified in Recommendation A06-10.

Therefore, the response to Recommendation A06-10 is assessed as Unsatisfactory.

Next TSB action

TC and the FAA have no further planned activities to address the risks identified in Recommendation A06-10. The TSB will continue to investigate accidents where a PIF occurs, and monitor the industry for advances in technology to reduce the risk and incidence of PIF in impact-survivable accidents, and communicate those to TC and the FAA. However, as continued assessments will not likely yield further results, this recommendation will not be reassessed on a regular basis.

This deficiency file is Dormant.